摘要
研究了稀土（0．1％～1．2％）对AZ31B变形镁合金组织和力学性能的影响。结果表明：在AZ31B变形镁合金中添加稀土后，晶粒显著粗化，合金的室温力学性能下降。晶粒粗化一方面是由于RE与Al结合生成了Al11RE3相，消耗了一部分铝量，削弱了铝对α-Mg晶粒的细化作用；另一方面RE与ε-AlMn相反应生成Al-RE-Mn相，使得合金熔体中的异质形核核心减少；稀土引起AZ31B变形镁合金晶粒粗化在热分析曲线上表现为初晶形核最低温度从628．8下降到626．3℃，初晶再辉温差从0．8℃上升到3．2℃。
The effects of rare earth on the microstructure and mechanical properties of AZ31B wrought magnesium alloy were investigated. The results show that when adding rare earth into AZ31B wrought magnesium alloy, the grains are coarsened remarkably, as a result the mechanical properties decline. The causes for the grain coarsening are as follows： RE reacts with Al to form Al11RE3 phases, consumes a part of Al atoms, and weakens the grain refinement effect of AI on the α-Mg grains. RE reacts with ε-AlMn phases to form Al-RE-Mn compounds, thus reducing the amounts of heterogeneous nuclei in the melt. As a result of the grain coarsening of AZ31B wrought magnesium alloy by rare earth, the lowest temperature for primary phase nucleation decreases from 628.8 ℃ to 626.3 ℃ and the temperature difference of recalescence increases from 0.8 ℃ to 3.2 ℃.
出处
《中国有色金属学报》
EI
CAS
CSCD
北大核心
2006年第2期197-204,共8页
The Chinese Journal of Nonferrous Metals
基金
北京市科技计划资助项目(Y0405004040211)
关键词
AZ31B变形镁合金
稀土
晶粒尺寸
热分析
力学性能
AZ31B wrought magnesium alloy
rare earth
grain size
thermal analysis
mechanical property
